With the development of the times, the electronic industry develops on the basis of the development and application of Electronic Science and technology. Electronic industry is one of the pillar industries of the national economy, and it is a new industry of science and technology development. Cable protection is particularly important. Using Jinan cable tray can avoid the damage of cable life caused by dust and corrosion. The following is how to repair and protect the cable tray to prolong its service life and reduce the cost of maintenance.

济南电缆桥架

Jinan cable bridge

一、电缆桥架的修 复工作

1、 Repair of cable tray

1.锈迹处理

1. Rust treatment

通常济南电缆桥架采用氯磺化底漆二道进行两部分除锈，表面除锈处理质量直接影响防腐工程的寿命，现场除锈通常是砂轮机或者人工除锈，在表面处理之后，在4小时内涂上底漆。如果处理不当发现有新锈，必 需进行重新处理。

Generally, Jinan cable bridge adopts two layers of chlorosulfonated primer for two-part derusting. The quality of surface derusting treatment directly affects the service life of anti-corrosion engineering. The on-site derusting is usually done by grinding machine or manual derusting. After the surface treatment, the primer is applied within 4 hours. If new rust is found after improper treatment, it must be treated again.

2.涂层处理

2. Coating treatment

涂层工艺分为刷涂、滚涂。刷涂或者滚涂时每层应从横交错反复进行涂，直到均匀为止，不能出现漏涂。

The coating process is divided into brush coating and roll coating. When brushing or rolling coating, each layer shall be applied repeatedly and crosswise until it is uniform, and there shall be no missing coating.

3.施工环境要求

3. Construction environment requirements

环境需要通风良好，温度在13℃-30℃，不得低于5℃，相对湿度保持在80%以内。不宜在强烈日光下施工。遇到雨、雾、强风气候不得在室外进行施工。

The environment needs to be well ventilated, the temperature should be between 13 ℃ and 30 ℃, not lower than 5 ℃, and the relative humidity should be kept within 80%. It is not suitable for construction in strong sunlight. In case of rain, fog and strong wind, construction shall not be carried out outdoors.

二、电缆桥架的维护

2、 Maintenance of cable tray

1.避免摆放在高温潮湿地方。

1. Avoid placing in hot and humid places.

2.避免与腐蚀性液体接触。

2. Avoid contact with corrosive liquid.

3.可用电缆桥架专用的保养蜡进行保养。

3. Special maintenance wax for cable tray can be used for maintenance.

4.定期清理济南电缆桥架表面的灰尘与锈迹。

4. Regularly clean the dust and rust on the surface of Jinan cable tray.

济南电缆桥架

Jinan cable bridge

以上就是济南电缆桥架的修复与维护工作，电缆桥架也可以适用于电厂、化工、石化等领域，因为有耐腐蚀的电缆桥架，特别适用于具有高腐蚀环境的场所。

The above is the repair and maintenance work of Jinan cable tray. Cable tray can also be used in power plant, chemical industry, petrochemical and other fields, because there are corrosion-resistant cable tray, especially suitable for places with high corrosion environment.